Questions and Answers About Using a Pressure Canner

What Are the Steps for Successful Pressure Canning? (Read through all the instructions provided with your equipment before beginning.) 1. Put 2 to 3 inches of hot water in the canner. Place fi lled jars on the rack, using a jar lifter. Fasten the canner lid securely. 2. Leave weight off the vent port or open the petcock. Heat at the highest setting until steam fl ows from the petcock or vent port. 3. Maintain a high heat setting, exhaust steam 10 minutes and then place a weight on the vent port or close the petcock. The canner will pressurize during the next three to fi ve minutes. 4. Start timing the process when the pressure reading on the dial gauge indicates that the recommended pressure has been reached or when the weighted gauge begins to jiggle/rock. 5. Regulate the heat under the canner to maintain a steady pressure at or slightly above the correct gauge pressure. If the pressure reading goes below the recommended pressure, you must bring the pressure back up and start the timing process over again from the beginning. 6. When the timed processing is completed, turn off the heat, remove the canner from the heat (if you are using an electric range) and let the canner “depressurize” at room temperature. (The dial needle moves back to “0” or no steam sounds when the weight is nudged gently.) Do not force-cool the canner. Releasing pressure from a partially opened vent or placing the canner under cool water will result in underprocessing. It also may cause unsealed jars and loss of liquid from the jars. Quick-cooling also can warp the canner lid of older model canners. 7. After the canner is depressurized, remove the weight from the vent port or open the petcock. Wait two minutes, unfasten the lid and remove it carefully. Lift the lid away from you so that the steam does not burn your face. 8. Remove the jars with a lifter and place them on a towel or cooling rack, if desired. Do not set the jars on a cold surface or expose them to breezy conditions, which could lead to breaking of the jars. IMPORTANT: If at any time the pressure goes below the recommended amount, bring the canner back to pressure and begin the timing of the process over from the beginning (using the total original process time). This is important for the safety of the food. Always operate your pressure canner according to the manufacturer’s directions. Only use canners that have an Underwriter’s Laboratory (UL) approval. What Are Some Common Errors Using a Pressure Canner? These problems can pose safety issues: ● Air trapped in the closed canner during processing. Air trapped in a pressure canner lowers the temperature and this results in underprocessing. To be safe, all pressure canners must be vented for 10 minutes before they are pressurized. ● Using an inaccurate dial gauge. Gauges should be checked for accuracy each year before the canner is used. If the gauge reads high or low by more than 1 pound at 5, 10 or 15 pounds of pressure, replace it. Weighted gauges are always accurate. If your canner has both a gauge and weight, go by the weight, using the gauge as a guide. How Should a Pressure Canner be Stored? Make sure your canner is clean and dry before storing it. Air should reach the inside of the canner to prevent a stale odor from forming. Put crumpled paper inside the canner and wrap the lid in paper or place it in a paper bag. Turn the lid upside down in the canner instead of sealing the canner shut. If storage space is available, place the lid in a paper bag and store it right side up on a shelf. For more information on this and other topics, see . (Click on “Nutrition, Food Safety and Health, then “Food Preservation and Storage”) Source: National Center for Home Food Preservation at The NDSU Extension Service does not endorse commercial products or companies even though reference may be made to tradenames, trademarks or service names. This publication may be copied for noncommercial, educational purposes in its entirety with no changes. Requests to use any portion of the document (including text, graphics or photos) should be sent to . Include exactly what is requested for use and how it will be used. County commissions, North Dakota State University and U.S. Department of Agriculture cooperating. North Dakota State University does not discriminate on the basis of race, color, national origin, religion, sex, disability, age, Vietnam Era Veterans status, sexual orientation, marital status, or public assistance status. Direct inquiries to the Chief Diversity Offi cer, 205 Old Main, (701) 231-7708. This publication will be made available in alternative formats for people with disabilities upon request, (701) 231 7881.