ASE PREP ASSOCIATE LATEST UPDATED 2025/2026 Practice Exam WITH COMPLETE Questions AND SURE VERIFIED SOLUTIONS 100% FULLY SOLVED GRADED AT A+ SCORE!!

ASE PREP ASSOCIATE LATEST UPDATED 2025/2026 Practice Exam WITH COMPLETE Questions AND SURE VERIFIED SOLUTIONS 100% FULLY SOLVED GRADED AT A+ SCORE!! 1. Brake Pad Minimum Thickness Customer Pay Warranty CPO - ANSWER Customer Pay: 3mm Warranty: 4mm (3.9mm) CPO: 5 mm 2. What should you do after a brake pad replacement? - ANSWER Check brake fluid level and break in pads 3. Why do you perform brake a fluid flush? - ANSWER Fluid absorbs water and moisture - DOT 4 or higher (can go up in fluid, not down) 4. What will effect ride height? - ANSWER - Loading of vehicle, bent/damaged suspension components 5. Brake vibration 2k miles after brakes - ANSWER improper lug torque (over torqued) 6. Micro encapsulated bolts are used to - ANSWER lock threads 7. Brake bleed pressure setting (bar): - ANSWER 2 bar max - Location of MSDS: - ANSWER Online 8. CPO test drive (length and distance): - ANSWER 20 uninterrupted minutes/ 5 continuous miles 9. Caliper bleeding with 2 bleed screws - ANSWER Outer bleeder first, then inner - Is prescription eye wear valid eye protection in a bmw shop? - ANSWER no 10. How do you measure a vehicle wheel base? - ANSWER Center of front wheel to center of rear wheel 11. What does OL reading mean on DVOM? - ANSWER Open circuit 12. What can effect starter operation? - ANSWER Battery cable length, cable diameter, loose connections, corrosion, high resistance 13. Brake calipers are seized and the master cylinder cap seal is swollen. What could cause this? - ANSWER Oil - If found swollen, replace all rubber components 14. What is a refractometer? - ANSWER - Tool to measure concentration of mixture 15. What sensor calculates density or volume of air? - ANSWER MAF (mass air flow) CORRECT ANSWER -MAP (manifold absolute pressure) INCORRECT ANSWER 16. Leaking shock/strut- out of warranty (customer pay situation) - ANSWER - Replace both shocks/struts 17. Bolt sizing example: What is a 9.8? - ANSWER Grade of bolt/ tensile strength (Higher number = Stronger) 18. What can cause cupped tires? - ANSWER Worn struts/ suspension, imbalance/ bonds 19. What can cause wear on outside of tires? - ANSWER Alignment, bent or worn components, under inflation of tires 20. Pull concerns Brake and Suspension - ANSWER Seized pistons, blocked hose, frozen slides, alignment angles 21. BMW's max allowed V-drop in a circuit (small gauge wire) - ANSWER - .3v (300 mV) 22. What can cause tire wear in the middle of a tire? - ANSWER Over inflation - When do you wear safety glasses? - ANSWER Removing battery, suspension work, etc. 23. When does factory warranty expire? - ANSWER 4 years, 50k miles from in service date can be found on DCS warranty info